Iveco Stralis Rfc Fault Codes Page

Because the RFC box is mounted on the chassis (often behind the diesel tank or near the rear axle), it is exposed to road salt and water. Over time, water can seep into the unit or its connectors, causing "short to ground" errors (like

Its primary functions include:

Blown bulb, short circuit, or open circuit in left rear light wiring. Left Side & Rear Direction Lights iveco stralis rfc fault codes

| | Description | Severity | Common Cause | |---------------------|-----------------|--------------|------------------| | RFC 001 | DPF Soot Load Too High (Above 140%) | High – Limp mode | Frequent short trips, faulty differential pressure sensor. | | RFC 019 | Exhaust Gas Temperature Sensor 1 (Before DPF) – Plausibility Error | Medium | Sensor failure, wiring harness chafing near the turbo. | | RFC 032 | Diesel Exhaust Fluid (AdBlue) Quality Fault | Medium | Contaminated DEF, wrong fluid, crystallization in tank. | | RFC 045 | EGR Valve Position – RFC Conflict (Stuck Open/Closed) | High | Carbon buildup, failed EGR actuator, low engine compression. | | RFC 078 | Fuel Dosing Unit – Open Circuit | High – No regeneration | Broken wire at the dosing injector connector, corroded pins. | | RFC 092 | DPF Differential Pressure – Plausibility (Signal out of range) | Medium | Hoses melted or clogged with soot, sensor offset. | | RFC 113 | Engine Torque Derate Active – Forced by RFC | Info only | Consequence of other RFC faults – triggers limp mode. | | RFC 141 | Ash Accumulation – Permanent DPF Limitation | High – Replace DPF | Engine oil consumption, poor fuel quality, high mileage (>500,000 km without cleaning). | Because the RFC box is mounted on the

If you receive codes related to "Communication Timeout" or "CAN Line Malfunction," the issue may be deeper. | | RFC 019 | Exhaust Gas Temperature